Toyota Camry
XV30 (2002–2006) Service Manual
Lubrication
Under hood

GENERAL MAINTENANCE

1. GENERAL NOTES

Maintenance items may vary from country to country. Check the owner’s manual supplement in which the maintenance schedule is shown.
Every service item in the periodic maintenance schedule must be performed.
Periodic maintenance service must be performed according to whichever interval in the periodic maintenance schedule occurs first, the odometer reading (miles) or the time interval (months).
Maintenance service after the last period should be performed at the same interval as before unless noted.
Failure to do even one of the items can cause the engine to run poorly and increase the exhaust emissions.

2. WINDSHIELD WASHER FLUID

a. Check if there is sufficient fluid in the tank.

3. ENGINE COOLANT LEVEL

a. Check if the coolant level is between the ”FULL” and ”LOW” lines on the see−through reservoir.

4. RADIATOR AND HOSES

Check if the front of the radiator is clean and not blocked by leaves, dirt or bugs.
Check the hoses for cracks, kinks, rot or loose connections.

5. BATTERY ELECTROLYTE LEVEL

a. Check if the electrolyte level of all the battery cells is between the upper and lower level lines on the case.

6. BRAKE FLUID LEVEL

a. Check if the brake fluid levels are near the upper level line on the see−through reservoirs.

7. ENGINE DRIVE BELT

a. Check the drive belt for fraying, cracks, wear or oiliness.

8. ENGINE OIL LEVEL

a. Check the level on the dipstick with the engine turned off.

9. POWER STEERING FLUID LEVEL

Check the level on the dipstick.
The level should be in the ”HOT” or ”COLD” range depending on the fluid temperature.

10. AUTOMATIC TRANSMISSION FLUID LEVEL

Park the vehicle on a level surface.
With the engine idling and the parking brake applied, shift the selector into all the positions from ”P” to ”L”, and then shift into the ”P” position.
Pull out the dipstick and wipe off the fluid with a clean shop rag. Re−insert the dipstick and check that the fluid level is in the ”HOT” range.
Perform this check with the fluid at the normal driving temperature: 70 to 80°C (158 to 176°F).

HINT: Wait until the engine cools down (approx. 30 min.) before checking the fluid level after extended driving at high speed, in hot weather, in heavy traffic or pulling a trailer.

11. EXHAUST SYSTEM

a. If any change in the sound of the exhaust or the smell of the exhaust fumes is noticed, locate and correct the cause.

More about «Lubrication»: